盐析辅助水蒸气蒸馏法制备红松壳挥发油研究

doi:10.3969/j.issn.1000-2006.2016.06.019

国家林草科技领军期刊
中国精品科技期刊
中国高校百佳科技期刊
江苏省新闻出版政府奖期刊奖
RCCSE林学权威期刊（A+）
CSCD核心期刊
Scopus数据库收录期刊
中文核心期刊
SCD核心期刊

作者加群：102861116

微信公众号：南京林业大学学报

高级检索

南京林业大学学报（自然科学版） ›› 2016, Vol. 59 ›› Issue (06): 122-128.doi: 10.3969/j.issn.1000-2006.2016.06.019

盐析辅助水蒸气蒸馏法制备红松壳挥发油研究

宗芳芳,包怡红,李德海^*,郭宏鑫,徐颖,顾嘉林

东北林业大学林学院,黑龙江哈尔滨 150040

出版日期:2016-12-18 发布日期:2016-12-18
基金资助:
基金项目:中央高校基本科研业务费专项资金项目(2572014EA02); 黑龙江省教育厅科学技术研究项目(12543015)
第一作者:宗芳芳(coldfront_cool@126.com)。
*通信作者:李德海(lidehaineau@163.com),副教授。
引文格式:宗芳芳,包怡红,李德海,等. 盐析辅助水蒸气蒸馏法制备红松壳挥发油研究[J]. 南京林业大学学报(自然科学版),2016,40(6):122-128.

The preparation and component analysis of pine shell volatile oil by salting out-assisted steam distillation

ZONG Fangfang,BAO Yihong,LI Dehai^*,GUO Hongxin,XU Ying,GU Jialin

College of Forestry, Northeast Forestry University, Harbin 150040,China

Online:2016-12-18 Published:2016-12-18

摘要/Abstract

摘要： 采用盐析辅助水蒸气蒸馏法(salt out-assisted steam distillation,SOSD)制备红松壳挥发油,探讨无机盐对蒸馏方式的影响,通过单因素试验研究了蒸馏时间、固液比、无机盐、磷酸氢二钠的质量浓度、萃取剂等因素对红松壳挥发油提取率的影响,并采用气相色谱-质谱联用技术对红松壳挥发油成分进行分析。结果表明:SOSD法最佳制备工艺条件为蒸馏时间3 h,固液比1:9(g/mL),盐析效果最好的无机盐为4×10^-3 g/mL磷酸氢二钠,在此条件下红松壳挥发油提取率为0.9%,是水蒸气蒸馏法(steam distillation,SD)制备红松壳挥发油提取率(0.64%)的1.4倍。红松壳挥发油成分分析表明:SOSD法提取红松壳挥发油共分析出17种可能成分,而SD提取红松壳挥发油共分析出16种可能成分,两种方法提取结果有9种相同可能成分,如反-α反-α,α-5-三甲基-5-乙烯基四氢化-2-呋喃甲醇、苯甲醛、左旋樟脑、2-茨醇、(1R)-(+)-诺蒎酮、2,6,6-三甲基双环[3.1.1]庚-2-烯、2-(4-甲基苯基)丙-2-醇、4,6,6-三甲基二环[3.1.1]庚-3-烯-2-酮、3-甲基-6-(1-甲基亚乙基)-2-环己烯-1-酮等,其相对百分含量差别不大。

Abstract: The volatile oil of pine shell was extracted by salt out-assisted steam distillation to discuss effect of inorganic salt in the process of steam distillation. The distillation time, solid-liquid ratio, the inorganic salt type and its concentration, extraction agent on the yield of pine shell volatile oil were studied by single factor tests, while the constituents of pine shell volatile oil was analyzed by the gas chromatograph/mass spectrom(GC/MS). The results showed that the optimized extraction technology of the salting out-assisted steam distillation was distillation time for 3 h, solid-liquid ratio for 1:9(g/mL), best salting out effect was 4×10^-3 g/mL disodium hydrogen phosphate. The yield of volatile oil was up to 0.9% under these conditions, that is steam distillation method prepared pine shell volatile oil extraction rate(0.64%)of 1.4 times. The results of pine shell volatile oil components analysis showed that 17 species components in the pine shell volatile oil prepared by salting out-assisted steam distillation were identified by GC/MS, and 16 species components in the pine shell volatile oil prepared by steam distillation. There are the same nine species components in two kinds of essential oil, 2-furanmethanol,5-ethenyltetrahydro-5-trimethyl; benzaldehyde; bicyclo[2.2.1]heptan-2-one, 1,7,7-trimethyl-,(1S); bicyclo[2.2.1]heptan-2-ol,1,7,7-trimethyl; bicyclo[3.1.1]heptan-2-one,6,6-dimethyl-,(1R); bicyclo[3.1.1]heptan-2-one,3,6,6-trimethyl, benzenemethanol,4-trimethyl; bicyclo[3.1.1]hept-3-en-2-one,4,6,6- trimethyl, 2-cyclohexen-1-one,3-methyl-6-(1-methylethenyl). The relative percentage of 9 kinds of components is almost equal.

中图分类号:

TQ420

宗芳芳,包怡红,李德海,等. 盐析辅助水蒸气蒸馏法制备红松壳挥发油研究[J]. 南京林业大学学报（自然科学版）, 2016, 59(06): 122-128.

ZONG Fangfang,BAO Yihong,LI Dehai,GUO Hongxin,XU Ying,GU Jialin. The preparation and component analysis of pine shell volatile oil by salting out-assisted steam distillation[J].Journal of Nanjing Forestry University (Natural Science Edition), 2016, 59(06): 122-128.DOI: 10.3969/j.issn.1000-2006.2016.06.019.

参考文献

[1] Liu R, Xu B. Characterization of essential oil in pine nut shells [J]. Food Anal Methods, 2012, 5: 435-440. Doi:10.1007/S/2161-011-9264-7.
[2] Ferramosca A, Savy V, Conte L, et al. Dietary combination of conjugated linoleic acid(CLA)and pine nut oil prevents CLA induced fatty liver in mice[J]. Journal of Agricultural and Food Chemistry, 2008, 56(17): 8148-8158.Doi:10.1021/jf8010728.
[3] Cai L, Xiao L, Liu C, et al. Functional properties and bioactivities of pine nut(Pinus gerardiana)protein isolates and its enzymatic hydrolysates[J]. Food Bioprocess Technology, 2012, 6(18): 2109-2117.Doi:10.1007/S/1947-012-0885-7.
[4] 杨立宾. 红松种子蛋白提取与生理功能研究[D]. 哈尔滨: 东北林业大学, 2008. Yang L B. The protein of Korean pine seeds extract and physiological function [D]. Harbin:Northeast Forestry University, 2008.
[5] Kang Y H, Kim K K, Kim T W, et al. Anti-atherosclerosis effect of pine nut oil in high-cholesterol and high-fat diet fed rats and its mechanism studies in human umbilical vein endothelial cells[J]. Food Science Biotechnol, 2015, 24(1): 323-332.Doi:10.1007/S10068-015-0043-X.
[6] Wang Z Y, Chen X Q. Functional evaluation for effective compositions in seed oil of Korean pine[J]. Journal of Forestry Research, 2004, 15(3): 215-217.Doi:10.1007/BF02911028.
[7] 苏晓雨. 红松松塔萜类成分及生物活性研究[D]. 哈尔滨: 哈尔滨工业大学,2006. Su X Y. Study on terpene components and bioactivity from pinecone of Pinus koraiensis[J].Harbin: Harbin Institute of Technology, 2006.
[8] Orav A, Kailas T, Liiv M. Analysis of terpenoic composition of conifer needle oils by steam distillation—extraction, gas chromatography and gas chromatography-mass spectrometry [J]. Chromatographia, 1996, 43(3):215-219.Doi:10.1007/bf02292955.
[9] 张大伟, 郝琳琳, 李明谦, 等. 红松松籽壳和松塔天然产物研究进展[J]. 时珍国医国药, 2012, 23(10): 2588-2590.Doi:10.3969/j.issn.1008-0805.2012.10.09. Zhang D W, Hao L L, Li M Q, et al. Natural products of pine pine cone and pine nut shells progress[J]. Lishizhen Med Mater Med Res, 2012, 23(10): 2588-2590.
[10] 高岩, 袁久志, 王禹孝, 等. 红松松针中黄酮类成分的分离与鉴定[J]. 沈阳药科大学学报, 2010, 27(7): 534-543.Doi:10.14066/j.cnki.cn21-1349/r.2010.07. Gao Y, Yuan J Z,Wang Y X, et al.Isolation and identification of flavonoids from pine needle of Pinus koraiensis Sieb.et Zucc[J]. Joumal of Shenyang Pharmaceutical University, 2010, 27(7): 534-543.
[11] 王智航, 张永红, 于婉婷,等. 红松松塔、松子壳研究进展及在畜牧业中应用可行性分析[J]. 国外畜牧学:猪与禽,2009, 29(4): 88-90.Doi:10.3969/j.issn.1001-0769.2009.04.042. Wang Z H, Zhang Y H, Yu W T, et al.Study progress of pine nut shell of pine cone, and in animal husbandry application feasibility analysis[J]. Foreign Animal Husbandry:Pigs and Poultry, 2009, 29(4): 88-90.
[12] Ioannou E, Koutsaviti A, Tzakou O, et al. The genus Pinus: a comparative study on the needle essential oil composition of 46 pine species [J]. Phytochem Rev, 2014,13(4): 741-768.Doi:10.1007/S/1101-014-9338-4.
[13] Nakano M, Itoh Y, Mizuno T, et al. Anti-HIV activity of alkaline extract from pine seed shells(Pinus koraiensis)[J]. Asia Pacific J Clin Nutr, 1998, 7(1): 84-87.
[14] 李明谦, 张鹏, 张大伟, 等. 红松松子壳多糖对Hela细胞增殖的影响[J].中国兽医学报, 2013, 33(3): 409-413.Doi:10.16303/j.cnki.1005-4545.2013.03.014. Li M Q, Zhang P, Zhang D W, et al. Effect of polysaccharides extracted from Pinus koraiensis pinon shell against Hela cells proliferation[J].Chinese Journal of Veterinary Science, 2013, 33(3): 409-413.
[15] 梁珍海, 刘海燕, 周玉开, 等. 南京紫金山主要植物挥发物成分与含量分析[J]. 南京林业大学学报(自然科学版), 2010, 34(1): 48-52.Doi:10.3969/j.issn.1000-2006.2010.01.011. Liang Z H, Liu H Y, Zhou Y K, et al.Analysis of ingredients and contents of volatile organic compounds from main plants in Nanjing Zijin Mountain[J]. Journal of Nanjing Forestry University(Natural Sciences Edition), 2010, 34(1): 48-52.
[16] 包怡红, 段伟丽, 王芳, 等. 响应面法优化艾叶精油的提取工艺及其化学成分分析[J]. 食品工业科技, 2015, 36(14): 287-292,298.Doi:10.13386/j.issn.1002-0306.2015.14.050. Bao Y H, Duan W L, Wang F, et al. Study on optimization of microwave-assisted extraction and chemical composition analysis of essential oil from Artemisia argyi leaves[J]. Science and Technology of Food Industry, 2015, 36(14): 287-292,298.
[17] 童红,唐军,张正方.响应面法优化微波辅助水蒸气提取薰衣草挥发油的工艺研究[J].中国调味品,2013,38(10):62-63.Doi:10.3969/j.issn.1000-9973.2013.10.015. Tong H, Tang J, Zhang Z F. Optimization of microwave extraction process condition of lavender essential oil by response surface methodology[J]. China Condiment, 2013, 38(10): 62-63.
[18] 潘晓梅. 关于盐效应及其在分离过程中应用的研究[D]. 天津: 天津大学, 2002. Pan X M. Study on the salt effect and its application in separation processes[D]. Tianjin:Tianjin University, 2002.
[19] 陈迅, 陆筱艾, 刘向程,等.盐析效应在水蒸气提取植物精油中作用分析[J].广州化工, 2015, 43(6): 112-113,175.Doi:10.3969/j.issn.1001-9677.2015.06.040 Chen X, Lu X A, Liu X C, et al. Salting out effect in steam extraction plant oils in the role of analysis [J]. Guangzhou Chemical Industry, 2015, 43(6): 112-113,175.
[20] Rivera L L, Vilarem G. Hydrodistillation of caraway by direct induction heating assisted by a magnetic field process[J]. Flavour and Fragrance Journal, 2007, 22(3): 178-183.Doi:10.1002/ffj.1777.
[21] 黄诚, 尹红, 沈吴诚, 等. 复合溶剂提取大蒜精油的工艺条件研究[J]. 食品科学, 2009, 30(6): 89-91.Doi:10.3321/j.issn.1002-6630.2009.06.016. Huang C, Yin H, Shen W C, et al. Garlic oil complex solvent extraction process Conditions [J]. Food Science, 2009, 30(6): 89-91.
[22] 苏晓雨. 红松种壳组成及多酚提取分离与抗氧化抗肿瘤功能研究[D]. 哈尔滨: 哈尔滨工业大学, 2010. Su X Y. Pine seed shell composition and polyphenol the antioxidant extraction and separation and anti-tumor function [D]. Harbin: Harbin Institute of Technology, 2010.

盐析辅助水蒸气蒸馏法制备红松壳挥发油研究

The preparation and component analysis of pine shell volatile oil by salting out-assisted steam distillation

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

编辑推荐

Metrics

本文评价

作者

读者

审稿