毛竹纳米纤维素晶体的制备及特征分析

doi:10.3969/j.issn.1000-2006.2013.04.018

国家林草科技领军期刊
中国精品科技期刊
中国高校百佳科技期刊
江苏省新闻出版政府奖期刊奖
RCCSE林学权威期刊（A+）
CSCD核心期刊
Scopus数据库收录期刊
中文核心期刊
SCD核心期刊

作者加群：102861116

微信公众号：南京林业大学学报

高级检索

南京林业大学学报（自然科学版） ›› 2013, Vol. 37 ›› Issue (04): 95-98.doi: 10.3969/j.issn.1000-2006.2013.04.018

毛竹纳米纤维素晶体的制备及特征分析

何文,尤骏,蒋身学,张齐生

南京林业大学竹材工程研究中心,江苏南京 210037

出版日期:2013-08-18 发布日期:2013-08-18
基金资助:
收稿日期:2012-07-05 修回日期:2013-01-07
基金项目:南京林业大学高层次人才引进基金项目
第一作者:何文,讲师,博士。E-mail: hewen2011@njfu.edu.cn。
引文格式:何文,尤骏,蒋身学,等. 毛竹纳米纤维素晶体的制备及特征分析[J]. 南京林业大学学报:自然科学版,2013,37(4):95-98.

Isolation and characterization analysis of cellulose nanocrystal from Moso bamboo

HE Wen, YOU Jun, JIANG Shenxue, ZHANG Qisheng

Center of Bamboo Engineering Research, Nanjing Forestry University, Nanjing 210037, China

Online:2013-08-18 Published:2013-08-18

摘要/Abstract

摘要： 以毛竹为原料,首先经过次氯酸钠和氢氧化钠溶液去除竹纤维中的木质素与半纤维素等成分,再通过30%硫酸溶液与超声波处理结合的方法分离出毛竹纳米纤维素晶体。通过扫描电镜(SEM)与透射扫描电镜(TEM)对分离过程中各阶段产物进行形态特征分析,研究结果表明,纳米纤维素晶体的直径在20～85 nm之间。傅里叶红外光谱(FTIR)与X射线衍射(XRD)分析显示,毛竹中的木质素以及半纤维素已基本被移去,α-纤维素以及纳米纤维素晶体的结晶度得到明显的提高。热重分析仪(TGA)分析显示各个分离阶段所得产物的热稳定性均高于原竹纤维,但纳米纤维素晶体的热稳定性较α-纤维素的略低。

Abstract: Cellulose was extracted from Moso bamboo by carrying out bleaching and alkali treatments with acidified sodium chlorite solution and sodium hydrate solution, and then cellulose nanocrystal was isolated from extracted cellulose with the combination of(30%)sulphuric acid and ultrasonic treatment. According to the scanning electron microscopy(SEM)and transmission electron microscopy(TEM), the diameter of cellulose nanocrystal was in the range of 20-85 nm. The results of fourier transform infrared(FTIR)spectroscopy and X-ray diffraction(XRD)showed that the hemicellulose and lignin were removed extensively from the extracted cellulose, and the crystallinity of isolated α-cellulose and cellulose nanocrystal were significantly increased. The thermal stability of bamboo at different purification stages was investigated by thermogravimetric analysis(TGA)and the thermal stability of the bamboo cellulose increased at every purification stages compared to the raw material, however, the cellulose nanocrystal showed a little lower thermal stability than that of isolated α-cellulose.

中图分类号:

TQ352.6

何文,尤骏,蒋身学,等. 毛竹纳米纤维素晶体的制备及特征分析[J]. 南京林业大学学报（自然科学版）, 2013, 37(04): 95-98.

HE Wen, YOU Jun, JIANG Shenxue, ZHANG Qisheng. Isolation and characterization analysis of cellulose nanocrystal from Moso bamboo[J].Journal of Nanjing Forestry University (Natural Science Edition), 2013, 37(04): 95-98.DOI: 10.3969/j.issn.1000-2006.2013.04.018.

参考文献

[1] 李小芳,丁恩勇,黎国康,等.一种棒状纳米微晶纤维素的物性研究[J].纤维素科学与技术,2001,9(2):29-36. Li X F, Ding E Y,Li G K,et al.The research of properties of one kind of rodlike nanocrystal cellulose[J].Cellulose Science and Technology, 2001,9(2):29-36.
[2] 蒋玲玲,陈小泉.纳米纤维素晶体的研究现状[J].纤维素科学与技术,2008,16(2):73-78. Jiang L L, Chen X Q. The research status of nanocrystal cellulose[J]. Cellulose Science and Technology, 2008,16(2):73-78.
[3] 叶代勇,黄洪,傅和青,等.纤维素化学研究进展[J]. 化工学报,2006,57(8):1782-1791. Ye D Y, Huang H, Fu H Q,et al. The development of cellulose chemistry[J]. Journal of Chemical Industry and Engineering, 2006,57(8):1782-1791.
[4] 杨淑惠.植物纤维化学[M].北京:中国轻工业出版社,2001.
[5] 叶代勇.纳米纤维素的制备[J].化学进展,2007,19(10):1568-1575. Ye D Y. The preparation of nanocellulose[J].Progress in Chemistry, 2007,19(10):1568-1575.
[6] Sherly A P, Doreen P, Spange S, et al. Solvatochromic and electrokinetic studies of banana brils prepared from steam-exploded banana ber[J]. Biomacromolecules, 2008,9(7):1802-1810.
[7] Mwaikambo Y, Ansell M P.The effect of chemical treatment on the properties of hemp, sisal, jute and kapok bres for composite reinforcement[J]. Applied Macromolecular Chemistry and Physics, 1999,272(1):108-116.
[8] Klemm D, Philipp B, Heinze T, et al. General considerations on structure and reactivity of cellulose[J]. Comprehensive Cellulose Chemistry,2004,12(3):130-165.
[9] 张齐生,关明杰,纪文兰.毛竹材质生成过程中化学成分的变化[J].南京林业大学学报:自然科学版,2002,26(2):7-10. Zhang Q S, Guan M J, Lan J W. The change of chemical composition of Moso-bamboo during growing[J]. Journal of Nanjing Forestry University:Natural Sciences Edition, 2002,26(2):7-10.
[10] 王汉坤,余雁,喻云水,等.不同竹龄毛竹材纤维饱和点的测定[J].南京林业大学学报:自然科学版,2010,34(6):91-94. Wang H K, Yu Y,Yu Y S, et al. The determination of Moso-bamboo fiber saturated point in different ages[J]. Journal of Nanjing Forestry University:Natural Sciences Edition, 2010,34(6):91-94.
[11] 李宁,白洋.竹纤维性质及其应用[J].纺织科技进展,2007,11(3):15-17. Li N, Bai Y. The application and properties of bamboo fiber[J].Progress in Textile Science, 2007,11(3):15-17.
[12] Segal L, Creely J J, Martin A E, et al. An empirical method for estimating the degree of crystallinity of native cellulose using the X-ray diffractometer[J]. Textile Research Journal, 2009,29(10):786-794.
[13] Johnson R K, Zink-sharp A, Glasser W G. Preparation and characterization of hydrophobic derivatives of TEMPO-oxidizednanocelluloses[J].Cellulose,2011,18(6):1599-1609.
[14] Alemdar A, Sain M. Isolation and characterization of nano bers from agricultural residues-wheat straw and soy hulls[J]. Bioresource Technology,2008,99(6):1664-1671.
[15] 王菊华. 新型功能性竹浆纤维的制备及结构与性能的研究[D]. 苏州:苏州大学,2008. Wang J H. The properties and structure of new functional bamboo fiber preparation[D]. Suzhou:Suzhou University, 2008.
[16] Moran J I, Alvarez V A, Cyras V P, et al. Extraction of cellulose and preparation of nanocellulose from sisal fibers[J]. Cellulose, 2008,15(1):149-159.
[17] Li R, Fei J, Cai Y,et al. Cellulose whiskers extracted from mulberry:A novel biomass production [J]. Carbohydrate Polymers, 2009,76(1):94-99.
[18] Soares S,Camino G,Levchik S.Comparative study of the thermal decomposition of pure cellulose and pulp paper[J]. Polymer Degradation and Stability, 1995,49(2):275-283.
[19] Rosa M F, Medeiros E S, Malmonge J A, et al. Cellulose nanowhiskers from coconut husk fibers:Effect of preparation conditions on their thermal and morphological behavior [J]. Carbohydrate Polymers, 2010,81(1):83-92.
[20] Xiao B, Sun X F, Sun R. Chemical, structural, and thermal characterizations of alkali-soluble lignins and hemicelluloses, and cellulose from maize stems, rye straw, and rice straw [J]. Polymer Degradation and Stability. 2001,74(2):307-319.

毛竹纳米纤维素晶体的制备及特征分析

Isolation and characterization analysis of cellulose nanocrystal from Moso bamboo

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 1

编辑推荐

Metrics

本文评价

作者

读者

审稿