水热-微波处理水曲柳顺纹压缩应力-应变本构关系

张燕; 佟达; 宋魁彦

doi:10.3969/j.issn.1000-2006.2013.04.020

张燕,佟达,宋魁彦

南京林业大学学报（自然科学版） ›› 2013, Vol. 37 ›› Issue (04) : 105-109.

PDF(726573 KB)

国家林草科技领军期刊
中国精品科技期刊
中国高校百佳科技期刊
江苏省新闻出版政府奖期刊奖
RCCSE林学权威期刊（A+）
CSCD核心期刊
Scopus数据库收录期刊
中文核心期刊
SCD核心期刊

作者加群：102861116

微信公众号：南京林业大学学报

高级检索

PDF(726573 KB)

南京林业大学学报（自然科学版） ›› 2013, Vol. 37 ›› Issue (04) : 105-109. DOI: 10.3969/j.issn.1000-2006.2013.04.020

研究论文

水热-微波处理水曲柳顺纹压缩应力-应变本构关系

张燕,佟达,宋魁彦^*

作者信息 +

Stress-strain constitutive relation of longitudinal compressed Fraxinus mandshurica Rupr. with hydrothermal-microwave treatment

ZHANG Yan, TONG Da, SONG Kuiyan^*

Author information +

文章历史 +

摘要

通过对水热-微波联合处理的水曲柳幼龄材和成熟材顺纹压缩过程中应力-应变关系和木材化学组分变化的分析,建立木材顺纹压缩应力-应变本构关系。结果表明:在水曲柳顺纹压缩的初始阶段,应力-应变符合线性的弹性虎克定律; 在弹塑性阶段,也基本符合线性的力学关系,建立的水曲柳幼龄材和成熟材顺纹压缩应力-应变本构关系由常数项(比例极限应力)和应力-应变线性关系表达式两部分构成; 相同顺纹压缩率下幼龄材弹性模量和应力大于成熟材,主要受到木材化学组分差异的影响。

Abstract

Stress-strain relationship of longitudinal compressed hydrothermal-microwave treated juvenile and mature northeast China ash wood and their chemical composition variation were analyzed. The stress-strain constitutive relation of longitudinal compressed wood were established. Results showed that at the beginning of compression, the curves followed the linear Hooke’s Law. Meanwhile, the curves primarily fit the linear mechanics relation at the elastic-plastic region. The founded stress-strain constitutive relation showed that both juvenile and mature wood longitudinal compression could be expressed by an equation consisting of a constant term(proportional ultimate stress)and stress-strain linear relationship. The higher modulus of elasticity(MOE)and stress of juvenile wood was caused mainly by the difference of wood components between juvenile and mature ash wood at the same longitudinal compression rate.

引用本文

EndNote

Ris (Procite)

Bibtex

导出引用

张燕,佟达,宋魁彦. 水热-微波处理水曲柳顺纹压缩应力-应变本构关系[J]. 南京林业大学学报（自然科学版）. 2013, 37(04): 105-109 https://doi.org/10.3969/j.issn.1000-2006.2013.04.020

ZHANG Yan, TONG Da, SONG Kuiyan. Stress-strain constitutive relation of longitudinal compressed Fraxinus mandshurica Rupr. with hydrothermal-microwave treatment[J]. JOURNAL OF NANJING FORESTRY UNIVERSITY. 2013, 37(04): 105-109 https://doi.org/10.3969/j.issn.1000-2006.2013.04.020

中图分类号： S781.7

参考文献

[1] 李坚. 木材科学 [M]. 哈尔滨:东北林业大学出版社,1994.
[2] 宋魁彦. 家具设计制造学 [M]. 哈尔滨:黑龙江人民出版社,2006. Song K Y. Furniture Design and Manufacture [M]. Harbin:Heilongjiang People’s Press, 2006.
[3] 陆文达. 木材改性工艺学 [M]. 哈尔滨:东北林业大学出版社,1993.
[4] Horvath B, Peralta P, Frazier C,et al. Thermal softening of transgenic Aspen [J]. BioResources, 2011, 6(2):2125-2134.
[5] Carole A, Vincent P, Brigitte C, et al. Concomitant changes in viscoelastic properties and amorphous polymers during the hydrothermal treatment of hardwood and softwood [J]. Journal of Agriculture Food Chemistry, 2009, 57(15):6830-6837.
[6] Funaoka M,Kako T, Abe I. Condensation of lignin during heating of wood [J]. Wood Science and Technology, 1990, 24(3):277-288.
[7] Tjeerdsma B F, Militz H. Chemical changes in hydrothermal treated wood:FTIR analysis of combined hydrothermal and dry heat-treated wood [J]. Holz als Roh-und Werkstoff, 2005, 63(2):102-111.
[8] 李大纲,李坚,刘一星. 热处理对消除水曲柳木材弯曲变形的影响 [J]. 南京林业大学学报:自然科学版, 2004, 28(3):23-26. Li D G, Li J, Liu Y X. Effects of heat treatment on permanent fixation bending deformation in wood of Fraxinus mandshurica [J]. Journal of Nanjing Forestry University:Natural Sciences Edition, 2004,28(3):23-26.
[9] 苗平,张文静. 汽蒸处理对木材横向渗透性的影响 [J]. 南京林业大学学报:自然科学版, 2009, 33(2):99-102. Miao P, Zhang W J. Effect of steaming treatment on transverse permeability of wood [J]. Journal of Nanjing Forestry University:Natural Sciences Edition, 2009, 33(2):99-102.
[10] 周利,卢晓宁,丁慧. 水热处理对杨木顺纹压缩性质的影响 [J]. 南京林业大学学报:自然科学版, 2008, 32(1):61-64. Zhou L, Lu X N, Ding H. Effect of hydrothermal treatment on longitudinal compression properties of poplar [J]. Journal of Nanjing Forestry University:Natural Sciences Edition, 2008, 32(1):61-64.
[11] Uhmeier A,Morooka T, Norimoto M. Influence of thermal softening and degradation on the radial compression behavior of wet spruce [J]. Holzforschung, 1998, 52(1):77-81.
[12] Rajeev G J, Graduate R J, Perry N P, et al. Nonisothermal radio frequency drying of red oak [J]. Wood Fiber Science, 2001, 33(3):476-485.
[13] Beat S, Barbara O, Graeme S. Temperature and moisture content behaviour in microwave heated wood prior to bending Mountain Ash(Eucalyptus regnans)[J]. European Journal of Wood and Wood Products, 2009, 67(2):237-239.
[14] Hofstetter K, Hellmich C, Eberhardsteiner J. Development and experimental validation of a continuum micromechanics model for the elasticity of wood[J]. European Journal of Mechanics-A/Solids, 2005, 24(6):1030-1053.
[15] 李青.国产榆木压缩木的研制[J].木材工业,2000,14(4):38-39. Li Q. Development of compressed wood from domestic elm [J]. China Wood Industry, 2000, 14(4):38-39.
[16] 宋魁彦,王逢瑚,宋宇宏. 榆木顺纹压缩弯曲技术 [J]. 林业科学,2004, 40(2):126-130. Song K Y, Wang F H, Song Y H. The techniques of elm longitudinal compressing and bending [J]. Scientia Silvae Sinicae, 2004, 40(2):126-130.
[17] 宋魁彦,李坚. 水热-微波处理对榆木软化和顺纹压缩及弯曲的影响 [J]. 林业科学, 2009, 45(10):120-125. Song K Y, Li J. Effect of hydrothermal-microwave treatment on softening and longitudinal compressing and bending elm wood [J]. Scientia Silvae Sinicae, 2009, 45(10):120-125.
[18] 全国造纸工业标准化技术委员会.GB/T 2677.8—1994造纸原料酸不溶木素含量的测定[S].北京:中国标准出版社,1994.
[19] 全国造纸工业标准化技术委员会.GB/T 2677.10—1995造纸原料综纤维素含量的测定[S].北京:中国标准出版社,1996.
[20] 轻工业部造纸工业科学研究所.GB/T 2677.4—1993造纸原料水抽出物含量的测定[S].北京:中国标准出版社,1993.
[21] Tan L F, Zhu D W, Zhou W B, et al. Preferring cellulose of Eichhornia crassipes to prepare xanthogenate to other plant materials and its adsorption properties on copper [J] Bioresource Technology, 2008, 99(10):4460-4466.
[22] 张士成,齐华春,刘一星,等.高温过热蒸汽处理对木材结晶性能的影响[J].南京林业大学学报:自然科学版,2010,34(5):164-166. Zhang S C, Qi H C, Liu Y X, et al. Impact on timber crystallization performance of superheated steam-treated wood under high temperature and pressure [J]. Journal of Nanjing Forestry University:Natural Sciences Edition, 2010, 34(5):164-166.
[23] 佟达,宋魁彦,李坚. 水热-微波软化处理对水曲柳弯曲的影响 [J]. 林业科学, 2011, 47(11):129-132. Tong D, Song K Y, Li J. Effect of hydrothermal-microwave softened treatment on bending ash wood [J]. Scientia Silvae Sinicae, 2011, 47(11):129-132.
[24] 周永东,傅峰,李贤军,等. 微波处理对桉木应力及微观构造的影响 [J]. 北京林业大学学报, 2009, 31(2):146-150. Zhou Y D, Fu F, Li X J,et al. Effects of microwave treatment on residue growth stress and microstructure of Eucalyptus urophylla [J]. Journal of Beijing Forestry University, 2009, 31(2):146-150.

基金

收稿日期:2012-07-19 修回日期:2012-12-30
基金项目:国家自然科学基金项目(31070489)
第一作者:张燕,博士生。*通信作者:宋魁彦,教授。E-mail:skuiyan@126.com。
引文格式:张燕,佟达,宋魁彦. 水热-微波处理水曲柳顺纹压缩应力-应变本构关系[J]. 南京林业大学学报:自然科学版,2013,37(3):105-109.