巴旦杏壳天然黄色素提取及其稳定性研究

doi:10.3969/j.issn.1000-2006.2013.01.019

国家林草科技领军期刊
中国精品科技期刊
中国高校百佳科技期刊
江苏省新闻出版政府奖期刊奖
RCCSE林学权威期刊（A+）
CSCD核心期刊
Scopus数据库收录期刊
中文核心期刊
SCD核心期刊

作者加群：102861116

微信公众号：南京林业大学学报

高级检索

南京林业大学学报（自然科学版） ›› 2013, Vol. 37 ›› Issue (01): 105-110.doi: 10.3969/j.issn.1000-2006.2013.01.019

巴旦杏壳天然黄色素提取及其稳定性研究

王凤洁,沈国良,李良,马少君,程贵刚,邹明旭

沈阳工业大学石油化工学院,辽宁辽阳 111003

出版日期:2013-02-18 发布日期:2013-02-18
基金资助:
收稿日期:2011-08-31 修回日期:2012-03-23
第一作者:王凤洁,副教授。E-mail: wangfengjie8802@126.com。
引文格式:王凤洁,沈国良,李良,等. 巴旦杏壳天然黄色素提取及其稳定性研究[J]. 南京林业大学学报:自然科学版,2013,37(1):105-110.

Extraction and stability of natural yellow pigment from almond shell

WANG Fengjie, SHEN Guoliang,LI Liang, MA Shaojun,CHENG Guigang,ZOU Mingxu

School of Petrochemical Engineering, Shenyang University of Technology, Liaoyang 111003,China

Online:2013-02-18 Published:2013-02-18

摘要/Abstract

摘要： 巴旦杏壳是巴旦杏加工过程中的废弃物,利用水/乙醇为浸提剂,在75 ℃,浸提时间为2 h,料液比为1 g:15 mL条件下,可提取巴旦杏壳黄色素及木质素。对提取出的黄色素稳定性进行了研究,结果表明,杏壳黄色素在避光条件下的稳定性较好,日光照射会影响黄色素稳定性; 杏壳黄色素在一定温度下稳定性较好,但当温度达到85 ℃时,吸光度明显下降; 蔗糖、pH对杏壳黄色素稳定性有影响; Na⁺、K、Ca²⁺、Mg²⁺等金属离子对杏壳黄色素稳定性没有明显影响,而Cu²⁺、Al³⁺对杏壳黄色素稳定性影响较大; 氧化剂对杏壳黄色素稳定性影响较大; 还原剂Vc对杏壳色素稳定性影响不大。

Abstract: Almond shell is processing waste from the almond process and it was used as the raw material for extracting pigment and lignin with water/ethanol as extractant at 75 ℃, 2 h, and the ratio of material to liquid was 1 g:15 mL. It was shown from the light stability results that the almond shell pigment was relatively stable in dark condition, but it was sensitive in the natural light and easily degradable. It was stable under 85 ℃,but the absorbance decreased obviously at 85 ℃. Sucrose and pH also influence the stability of pigment. In addition, Na⁺,K⁺,Ca²⁺,Mg²⁺ had little effect on the stability of almond shell pigment, but Cu²⁺ and Al³⁺ were effect on the pigment stability seriously. Oxidants were effect on stability of the pigment very much. Vc was little effect on the almond shell pigment. This research provides a reference for development and utilization of natural almond shell pigment.

中图分类号:

TS202.3

王凤洁,沈国良,李良,等. 巴旦杏壳天然黄色素提取及其稳定性研究[J]. 南京林业大学学报（自然科学版）, 2013, 37(01): 105-110.

WANG Fengjie, SHEN Guoliang,LI Liang, MA Shaojun,CHENG Guigang,ZOU Mingxu. Extraction and stability of natural yellow pigment from almond shell[J].Journal of Nanjing Forestry University (Natural Science Edition), 2013, 37(01): 105-110.DOI: 10.3969/j.issn.1000-2006.2013.01.019.

参考文献

[1] 张李华.扁桃的开发价值及栽培技术[J].中国林副特产,2005(4):22,60. Zhang L H. Development value and cultivation technology of Amygdalus communis L.[J].Forest By-Product and Speciality in China,2005(4):22,60.
[2] 戈慧敏,张玉萍.扁桃的价值及开发前景[J].山西果树,2009(1):38-39. Ge H M,Zhang Y P.Value and development prospects of Amygdalus communis L.[J].Shanxi Fruits,2009(1):38-39.
[3] 侯纪展.扁桃的开发价值与栽培技术[J].特种经济动植物,2006(5):32-33. Hou J Z. Development value and cultivation technology of Amygdalus communis L.[J].Special Economic Animal and Plant, 2006(5):32-33.
[4] 潘永明.扁桃的开发潜力及引种栽培[J].牡丹江师范学院学报,2006,3(3):21-22. Pan Y M. Development potential and cultivation of Amygdalus communis L.[J]. Journal of Mudanjiang Teachers’ College, 2006,3(3):21-22.
[5] 买买提·吐尔逊,阿不力米提·那士,司马义·巴拉提.不同品种巴旦杏仁中微量元素及总黄酮含量的比较研究[J].广东微量元素科学,2009,16(7):25-29. Mamat Turson,Abulimit Nasir,Simayil Barat.Determination of trace elements and total flavone in different variant of Amygdalus communis L. for Uighur medicine[J]. Guangdong Trace Elements Science, 2009,16(7):25-29.
[6] 成健红,侯平,李疆,等.巴旦杏的产业发展及研究进展[J].干旱区研究,2000,17(1):32-37. Cheng J H,Hou P, Li J, et al. The industrial development of almond and its research states[J]. Arid Zone Research,2000, 17(1):32-37.
[7] 薛晓珍.新疆巴旦杏的主要营养成分及用途[J].仪器仪表与分析监测,2003(2):45-46. Xue X Z. Main nutrition and use of Xinjiang Amygdalus communis L.[J]. Instrumentation Analysis Monitoring,2003(2):45-46.
[8] 李芳,孔令明,杨清香,等.巴旦杏蛋白饮料的工艺优化及其稳定性研究[J].现代食品科 2009,25(7):786-789 Li F, Kong L M, Yang Q F, et al. Process optimization and its stability study on almond protein peverage[J].Modern Food Science and Technology,2009,25(7):786-789.
[9] 兰彦平,吐拉克孜,郭文英,等.巴旦杏的研究现状及开发利用前景[J].林业科学研究,2004,17(5):674-679. Lan Y P,Turakez,Guo W Y,et al. Research process and utilization on Amygdalus communis L.[J].Forest Research, 2004,17(5):674-679.
[10] 邵婧,韩泳平.核桃壳天然棕色素的稳定性研究[J]. 西南民族大学学报:自然科学版,2010,36(4):610-614. Shao J, Han Y P.Stability research of natural pigment from walnut shell[J].Journal of Southwest University for Nationalities:Natrual Science Edition,2010,36(4):610-614.
[11] 吴雪辉,黄敏胜,张远志,等.板栗壳食用色素的提取工艺条件研究[J].食品科技,2004(4):57-59. Wu X H, Huang M S, Zhang Y Z, et al.Study on the extraction technology of food pigment extracted from chestnut shell[J].Food Science and Technology, 2004(4):57-59.
[12] 郑剑.板栗壳棕色素提取工艺研究[D].昆明:西南林学院,2008. Zheng J. Study on the extraction technology of the brown pigment extracted from chestnut shell[D]. Kunming:Southwest Forestry College,2008.
[13] 刘俊辉,孙卫国,陈莉,等.板栗壳天然染料的提取及对毛织物的染色性能[J].毛纺科技,2008(12):13-16. Liu J H, Sun W G, Chen L, et al.Extraction of natural dyestuff from chestnut shell and research on the dyeing behaviour of wool fabric[J].Wool Textile Journal,2008(12):13-16.
[14] 刘平.板栗壳棕色素提取、纯化及抗氧化性的研究[D].武汉:武汉工业学院,2008. Liu P.The chestnut shell brown pigment extraction, purification and research of oxidation resistance[D]. Wuhan: Wuhan Polytechnic University, 2008.
[15] 王静.榛子壳棕色素提取、纯化及性质研究[D].哈尔滨:东北林业大学,2010. Wang J.The extraction, purification of brown pigment from hazelnut shells and research of its properties[D]. Harbin:Northeast Forestry University, 2010.
[16] 徐清海,明霞,李秉超.榛子壳棕色素的提取及稳定性研究[J]. 沈阳农业大学学报,2009,40(1):58-61. Xu Q H, Ming X, Li B C.The extraction of brown pigment from hazelnut shells and its stability[J]. Journal of Shenyang Agricultural University,2009,40(1):58-61.
[17] 陈忻,陈纯馨,张俊敏,等.从板栗壳中提取棕色素及棕色素理化性质的研究[J].食品科学,2003,23(11):52-53. Chen X, Chen C X, Zhang J M, et al. The extraction of brown pigment from chestnut shell and the research on physical and chemical properties of brown pigment[J].Food Science,2002,23(11):52-53.
[18] de Vasconcelos M C, Bennett R N, Quideau S, et al. Evaluating the potential of chestnut(Castanea sativa Mill.)fruit pericarp and integument as a source of tocopherols, pigments and polyphenols[J].Industrial Crops and Products, 2010, 31(2): 301-311
[19] Jun S J,Chun J K.Design of U-column microwave-assisted extraction system and its application to pigment extraction from food[J]. Food and Bioproducts Processing,1998,76(4):231-236.
[20] Hawthorne S B, Miller D J.Direct comparison of soxhlet and low-and high-temperature supercritical CO₂ extraction efficiencies of organics from environmental solids[J]. Analytical Chemistry,1994,66(22):4005-4012.
[21] 姚成立, 毕建洪.天然色素的提取和研究进展[J].安徽化工2007,33(3):1-3,25. Yao C L, Bi J H.Progress on research of new techniques for extraction and study of natural pigments[J].Anhui Chemical Industry,2007,33(3):1-3,25.
[22] 李忠正.可再生生物质资源—木质素的研究[J]. 南京林业大学学报:自然科学版,2012,36(1):1-7. Li Z Z. The study of renewable biomass resources-lignin[J]. Journal of Nanjing Forestry University:Natural Sciences Edition, 2012,36(1):1-7.

巴旦杏壳天然黄色素提取及其稳定性研究

Extraction and stability of natural yellow pigment from almond shell

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 1

编辑推荐

Metrics

本文评价

作者

读者

审稿